Trane Performance Air Handlers Manual de Instalação Página 5
- Página / 132
- Índice
- RESOLUÇÃO DE PROBLEMAS
- MARCADORES
Avaliado. / 5. Com base em avaliações de clientes
CLCH-SVX07C-EN 5
Table of Contents
Bottom Opening Duct Installation . . . . . . 81
Discharge Plenum Connections . . . . . . . 82
Bell Mouth Discharge Connections . . . . 82
Traq Damper Connections . . . . . . . . . . . . 83
External Face-and-Bypass Connections . 84
Other Connections . . . . . . . . . . . . . . . . . . 85
Coil Piping and Connections
. . . . . . . . . . . . . 86
General Recommendations
. . . . . . . . . . . . 86
Drain Pan Trapping
. . . . . . . . . . . . . . . . . . . 86
Steam Coil Piping
. . . . . . . . . . . . . . . . . . . . 87
Water Coil Piping
. . . . . . . . . . . . . . . . . . . . . 89
Refrigerant Coil Piping
. . . . . . . . . . . . . . . . 90
Liquid Lines . . . . . . . . . . . . . . . . . . . . . . . . 91
Suction Lines . . . . . . . . . . . . . . . . . . . . . . 92
Installation - Electrical
. . . . . . . . . . . . . . . . . . . 99
Quick Connects . . . . . . . . . . . . . . . . . . . . 101
Controls Interface
. . . . . . . . . . . . . . . . . . . . . . 104
Connecting the operator display
. . . . . . . 104
Setting up the operator display
. . . . . . . . 104
Calibrating the operator display
. . . . . . . 104
Adjusting brightness and contrast
. . . . . 104
External communications port
. . . . . . . . 105
Start-Up
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
Pre-Startup Checklist
. . . . . . . . . . . . . . . . . 106
General Checks . . . . . . . . . . . . . . . . . . . . 106
Fan-Related Checks . . . . . . . . . . . . . . . . 106
Coil-Related Checks . . . . . . . . . . . . . . . . 106
Motor-Related Checks . . . . . . . . . . . . . . 107
Unit Operation
. . . . . . . . . . . . . . . . . . . . . . 107
Calculate Motor Voltage Imbalance . . . 107
VFD Programming Parameters . . . . . . . 107
Tension the Fan Belt . . . . . . . . . . . . . . . 109
Determine Fan Speed . . . . . . . . . . . . . . 110
Align Fan and Motor Sheaves . . . . . . . . 111
Check Multiple Belts . . . . . . . . . . . . . . . . 111
Airflow Measuring Systems
. . . . . . . . . . . 111
Traq™ Dampers . . . . . . . . . . . . . . . . . . . 111
Fan Inlet Airflow Measuring System . . 117
Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . .117
Transmitter Sizing . . . . . . . . . . . . . . . . . .117
Transmitter Calibration . . . . . . . . . . . . . .117
Constant Factor K . . . . . . . . . . . . . . . . . . .118
Maintenance . . . . . . . . . . . . . . . . . . . . . . .120
External Insulating Requirements
. . . . . . .120
Routine Maintenance
. . . . . . . . . . . . . . . . . . .121
Maintenance Checklist
. . . . . . . . . . . . . . . .121
Air Filters
. . . . . . . . . . . . . . . . . . . . . . . . . . . .122
Throwaway Filters . . . . . . . . . . . . . . . . . .122
Permanent Filters . . . . . . . . . . . . . . . . . . .122
Cartridge or Bag Filters . . . . . . . . . . . . . .122
Drain Pans
. . . . . . . . . . . . . . . . . . . . . . . . . . .122
Fans
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .123
Inspecting and Cleaning Fans . . . . . . . . .123
Bearing Set Screw Alignment . . . . . . . . .123
Torque Requirements . . . . . . . . . . . . . . .124
Fan Bearing Lubrication . . . . . . . . . . . . .124
Motor Bearing Lubrication . . . . . . . . . . .124
Fan Motor Inspection . . . . . . . . . . . . . . . .124
Coils
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .125
Steam and Water Coils . . . . . . . . . . . . . .125
Refrigerant Coils . . . . . . . . . . . . . . . . . . . .125
Coil Winterization . . . . . . . . . . . . . . . . . . .126
Moisture Purge Cycle . . . . . . . . . . . . . . . .126
Cleaning Non-Porous Surfaces . . . . . . . .127
Cleaning Porous Surfaces . . . . . . . . . . . .127
Ultraviolet (UV) Light Maintenance
. . . . .128
Cleaning the Bulbs . . . . . . . . . . . . . . . . . .128
Replacing the Bulbs . . . . . . . . . . . . . . . . .128
Disposal of Bulbs . . . . . . . . . . . . . . . . . . .128
Troubleshooting
. . . . . . . . . . . . . . . . . . . . . . . .129
- Installation, Operation 1
- Important 2
- Environmental Concerns! 2
- CLCH-SVX07C-EN 3 3
- Table of Contents 4
- Introduction 6
- General Information 7
- Required! 8
- Pre-Installation Requirements 9
- Storage Recommendations 10
- Preparing the Unit Site 10
- Microbial Growth! 11
- Unit Dimensions and Weights 12
- Fans/Motors 20
- Installation - Mechanical 21
- Unit Placement and Assembly 25
- Unit Assembly 26
- Ceiling Suspension 26
- Risk of Unit Dropping! 26
- Hole diameter 27
- CLCH-SVX07C-EN 29 29
- Detail A 32
- Butyl tape 32
- Outdoor Unit Weather Hoods 34
- Stacked Outdoor Units 34
- Unit assembly 35
- Flashing Installation 37
- Detail C 39
- Flashing Installation Notes 40
- Install flashing and hood 41
- Assembly 42
- External Raceway Assembly 44
- Diffuser Section 45
- Filter Section 45
- Filter Placement 46
- CLCH-SVX07C-EN 47 47
- 48 CLCH-SVX07C-EN 48
- CLCH-SVX07C-EN 49 49
- 50 CLCH-SVX07C-EN 50
- CLCH-SVX07C-EN 51 51
- 52 CLCH-SVX07C-EN 52
- CLCH-SVX07C-EN 53 53
- 54 CLCH-SVX07C-EN 54
- CLCH-SVX07C-EN 55 55
- 56 CLCH-SVX07C-EN 56
- Fan Section 62
- Seismic Application 63
- Requirements 63
- Hurricane Application 64
- Hurricane Unit Anchorage 65
- Gas Heat Installation 66
- Pipe Cabinet Installation 67
- 68 CLCH-SVX07C-EN 68
- Damper Section 69
- Damper Torque Requirements 70
- CLCH-SVX07C-EN 71 71
- 72 CLCH-SVX07C-EN 72
- CLCH-SVX07C-EN 73 73
- 74 CLCH-SVX07C-EN 74
- CLCH-SVX07C-EN 75 75
- 76 CLCH-SVX07C-EN 76
- CLCH-SVX07C-EN 77 77
- 78 CLCH-SVX07C-EN 78
- Multizone Modules 79
- Duct Connections 79
- Damper Connections 80
- CLCH-SVX07C-EN 81 81
- Discharge Plenum Connections 82
- Traq Damper Connections 83
- 84 CLCH-SVX07C-EN 84
- Other Connections 85
- Coil Piping and Connections 86
- Steam Coil Piping 87
- Breaker Cracking Pressure! 88
- Coil Condensate! 88
- Water Coil Piping 89
- Liquid Lines 91
- Valve Damage! 91
- Suction Lines 92
- Installation - Electrical 100
- Quick Connects 101
- Controls Interface 104
- External communications port 105
- Start-Up 106
- Unit Operation 107
- Tension the Fan Belt 109
- NOTICE: 109
- Belt Tension! (2 of 2) 109
- Determine Fan Speed 110
- Live Electrical Components! 110
- Align Fan and Motor Sheaves 111
- Check Multiple Belts 111
- Traq™ Dampers 111
- Transmitter Sizing 117
- Transmitter Calibration 117
- Constant Factor K 118
- Maintenance 120
- Routine Maintenance 121
- Air Filters 122
- Drain Pans 122
- Inspecting and Cleaning Fans 123
- Bearing Set Screw Alignment 123
- Rotating Components! 123
- Coil Winterization 126
- Moisture Purge Cycle 126
- Coil Freeze-up! 126
- Ultraviolet (UV) Light 128
- Troubleshooting 129
© 2020, manymanuals-pt.com. Todos os direitos reservados. | 0.051 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentários a estes Manuais